欢迎您！东篱公司
退出
-
申报数据库
-
立项数据库
-
成果数据库
-
项目获奖数据库
中文摘要：
苯胺甲醛缩合制多胺的反应是典型的第Ⅲ类反应体系,反应过程复杂。针对反应的阶段性特征,采用分段导数分析法对其进行反应器网络综合,第一阶段应采用DSR或PFR;第二阶段应采用PFR。采用不同的流程结构进行试验,结果为：采用DSR＋PFR的流程结构,最终产品中二氨基二苯甲烷（MDA）含量最高;采用PFR＋PFR的流程结构,最终产品中二氨基二苯甲烷（MDA）含量次之。试验结果与导数分析法分析结果一致,表明本文所用方法是有效的。
英文摘要：
Synthesis of polyamine from aniline and formaldehyde is a typical type III reaction system, so the reaction process is complex. In view of the stage characteristics of type III reaction system, piecewise derivative analysis was used to solve the problem of its reactor network synthesis. Differential side-stream reactor（DSR） or plug flow reactor （PFR） should be used in the first reaction stage and PFR should be used in the second reaction stage. A series of experiments with different process structures were done, and the results were compared with theoretical analysis. The results of the experiments showed that the amount of methylenedianiline （MDA） was the highest with the structure of DSR and PFR. The amount of MDA was the second highest with the structure of PFR and PFR. The experimental results were consistent with the piecewise derivative analysis results, indicating the effectiveness ofpiecewise derivative analysis.
同期刊论文项目
同项目期刊论文
Conceptual design and analysis of a passive residual heat removal system for a 10?MW molten salt rea
Effect of rolling motion on single-phase laminar flow resistance of forced circulation with differen
Microbubble emission boiling in scbcooled pool boiling and the role of Marangoni convection in its f
Slug behavior and pressure drop of adiabatic slug flow in a narrow rectangular duct under inclined c
Effects of void fraction correlations on pressure gradient separation of?air–water two-phase flow in
Experimental study of interfacial parameter distributions in upward bubbly flow under vertical and i
Effects of void fraction correlations on pressure gradient separation of air–water two-phase flow in
Comparison of local interfacial characteristics between vertical upward and downward two-phase flows
Local interfacial parameter distribution for two-phase flow under rolling conditions using a four-se
Effect of rolling motion on transient flow resistance of two-phase flow in a narrow rectangular duct
Investigation of the interfacial parameter distribution in a bubbly flow in a narrow rectangular cha
A theoretical analysis about the mechanism of the effect of rolling motion on single-phase flow resi
Effects of void fraction correlations on pressure gradient separation of air-water two-phase flow in
Evaluation of interfacial area transport equation in vertical bubbly two-phase flow in large diamete
Model of bubble velocity vector measurement in upward and downward bubbly two-phase flows using a fo
期刊信息
位置：