位置：成果数据库 > 期刊 > 期刊详情页
Leaching of Carbothermic Reduced Titanium-bearing Blast Furnace Slag by Acid
  • ISSN号：2095-9389
  • 期刊名称：《工程科学学报》
  • 时间：0
  • 分类：TG146[金属学及工艺—金属材料;一般工业技术—材料科学与工程;金属学及工艺—金属学]
  • 作者机构：北京科技大学钢铁冶金新技术国家重点实验室,北京100083
  • 相关基金：Projects（51474141;51174022）supported by the National Natural Science Foundation of China
作者： ZHEN Yulan, ZHANG Guohua, CHOU Kuochih
关键词： 氧化焙烧, 辉钼精矿, 形貌, 烧结, oxidation roasting, molybdenite concentrate, morphology, sintering
中文摘要：

为研究辉钼精矿的氧化焙烧机理分别在673、723、773、873、973 K下进行氧化焙烧实验。分别采用X射线衍射（XRD）和扫描电子显微镜（SEM）对氧化过程中产物的物相和形貌进行分析。结果表明,在纯氧条件下,Mo S2直接氧化成Mo O3,并且随着焙烧温度的升高,产物的形貌发生了明显变化。在纯氧气氛下,当温度高于873 K时有烧结现象发生,烧结物大部分是由氧化产物Mo O3组成,同时含有少量未氧化完全的Mo S2。

英文摘要：

In order to investigate the oxidation roasting of molybdenite concentrate in pure oxygen atmosphere, experiments at 673, 723, 773, 873 and 973 K were carried out. The phase transitions and morphology evolutions of the samples obtained at different temperatures after reacting for different time were analyzed by X-ray diffraction（XRD） and scanning electron microscopy（SEM）. The results showed that molybdenite concentrate was oxidized directly to Mo O3 in pure oxygen atmosphere. There were remarkable changes of the morphologies of products with the increase of the roasting temperature. It was also found that sintering phenomenon occurred during the roasting process in pure oxygen when the temperature was above 873 K. The composition of sintered sample was mainly comprised of Mo O3 and some unreacted Mo S2.

同期刊论文项目
闪烁炉中矿石还原过程的物理化学基础研究
期刊论文 1
冶金熔体的物理化学性质与组元的微观结构和粒子相互作用的关系
期刊论文 63 会议论文 5
利用熔渣电解对钢液进行脱氧和合金化
期刊论文 1
同项目期刊论文
A Structurally Based Viscosity Model for Oxide Melts
Effect of ozone on the performance of solid oxide fuel cell with Sm0.5Sr0.5CoO3 cathode
Thermodynamic Analysis of the Corrosion of Fe-16Cr Alloy Interconnect of Solid Oxide Fuel Cell under
Viscosity model for aluminosilicate melt
Model for calculating physicochemical properties of aluminosilicate melt
Reduction kinetics of metal oxides by hydrogen
Study on kinetics of hydrogen reduction of MoO2
Kineticsand mechanism of hydrogen reduction of ilmenite powders
Kinetics of reduction of titano-magnetite powder by H2
Non-isothermal reduction kinetics of titanomagnetite by hydrogen
Extermination of vanadium valence state in CaO-MgO-Al2O3-SiO2 system by high temperature mass spectr
An Investigation of Electro-deoxidation Process for Producing Titanium from Dense Titanium Dioxide C
Correlation between Viscosity and Electrical Conductivity of Aluminosilicate Melt
Modeling the viscosity of alumino-silicate melt
Estimation of sulfide capacities of multicomponent slags using optical basicity
Effect of TiO2 Addition on Crystallization Characteristics of CaO-Al 2 O 3-based Mould Fluxes for Hi
Effects of MgO and Al2O3addition on the redox state of chromium in CaO-MgO-Al2O3-SiO2 system
Evolution Mechanisms ofMgO·Al2O3 Inclusions by Cerium in Spring Steel Used in Fasteners of High-spee
Influence of TiN on viscosity of CaO-MgO-Al2O3-SiO2-(TiN)suspension system
Electrical conductivity and electronic/ionic properties of TiOx-CaO-SiO2 slags at various oxygen pot
Structureand Crystallization Kinetics of Glassy CaO-Al2O3-SiO2-CaF2-Na2O Mold Fluxeswith Varying Bas
Effectnof Agitation on Crystallization Behavior of CaO-Al2O3-SiO2-Na2O-CaF2 Mold Fluxes with Varying
Determination of vanadiumvalence state in CaO-MgO-Al2O3-SiO2 system byhigh temperature mass spectrom
Influence of TiO2 on viscosity of aluminosilicate melt
Influence of TiC on theviscosity of CaO-MgO-Al2O3-SiO2-TiC suspensionsystem
A morphological study ofthe reduction of MoO2 by hydrogen
Electronic/Ionic Propertiesof FexO-SiO2-CaO-Al2O3 Slags atVarious Oxygen Potentials and Temperatures
Influence of Al2O3/SiO2 ratio on viscosities of CaO-Al2O3-SiO2 melt
Influence of CaF2 on viscosity of aluminosilicate melts
Modeling the viscosity ofalumino-silicate melt
Effects of Cerium on Resistance to Pitting Corrosion of Spring Steel Used in Fasteners of High-Speed
Effect of cerium on the cleanliness of spring steel used in fastener of high-speed railway
Phase Transitions and Morphology Evolutions during Hydrogen Reduction of MoO3 to MoO2
The effects of temperature and oxygen pressure on the initial oxidation of stainless steel 441
Kinetics of carbothermic reduction of synthetic chromite
Dissolution Behavior of Al2O3 in Refining Slags Containing Ce2O3
Fe~(2+)和Fe~(3+)对含铁氧化物熔体性质的影响
铬铁矿高效还原的动力学分析
Measuring and modeling viscosity of CaO-Al2O3-SiO2 (-K2O) melt
Modelling viscosities ofCaO-MgO-Al2O3-SiO2 molten slags
Kinetics for gas-solid reactions involving dual-reaction interfaces
Study on hydrogen reduction of Mo4O11
Comparison of Different Calculation Methods of the New Generation Geometric Model in Predicting the
Modelling Viscosities of CaO-MgO-Al2O3-SiO2 Molten Slags
Viscosity model for fullyliquid silicate melt
An Insight into Slag Structure from Sulphide Capacities
Electrical conductivity of CaCl2-KCl-NaCl system at 1080 K
Measuring and Modeling Viscosity of CaO-Al2O3-SiO2(-K2O) Melt
Modeling Viscosities of CaO-MgO-FeO-MnO-SiO2 Molten Slags
Relation Between Viscosity and Electrical Conductivity of Silicate Melts
CaO-Al2O3-SiO2熔体电导率和离子扩散系数的研究
Modelling viscosities ofCaO-MgO-FeO-MnO-SiO2 molten slags
Estimating sulfide capacities for ternary systems with limited solubility
Reduction Kinetics of FeTiO3 Powder by Hydrogen
Simple Method for Estimating the Electrical Conductivity of Oxide Melts with Optical Basicity
CaO-Al2O3-SiO2熔体的电导率和离子扩散系数研究
Topography,structure,and formation kinetic mechanism of carbon deposited onto nickel in the temperature range from 400 to 850°C
MgO和MnO对CaO-SiO2-Fe2O3-P2O5渣的物相影响
期刊信息
  • 《工程科学学报》
  • 北大核心期刊（2011版）
  • 主管单位:中华人民共和国教育部
  • 主办单位:北京科技大学
  • 主编：张欣欣
  • 地址：北京市海淀区学院路30号
  • 邮编：100083
  • 邮箱：xuebaozr@ustb.edu.cn
  • 电话：010-62332875
  • 国际标准刊号：ISSN：2095-9389
  • 国内统一刊号：ISSN：10-1297/TF
  • 邮发代号:82-303
  • 获奖情况:
  • 首届国家期刊奖,第二届全国优秀科技期刊评比一等奖,全国高等学校自然科学学报系统优秀学报评比一等奖,中国期刊方阵“双高”期刊
  • 国内外数据库收录:
  • 日本日本科学技术振兴机构数据库,中国北大核心期刊（2004版）,中国北大核心期刊（2008版）,中国北大核心期刊（2011版）,中国北大核心期刊（2014版）
  • 被引量:392